www.marinedieseldirect.com is part of the TOAD Marine Supply. Order parts from this catalog online, by phone 616-820-0022, fax 616-396-1136 or email


Caution
General Information
Preparations For Starting
Before Starting
Starting Engine
Engine Break-in and General Running
Stopping the Engine
Decompression Lever
Instrument Panel
Wiring Diagram
Preparing Engine for Storage
Preparing Engine for Spring Service
Fuel Injection Timing
Diesel Valve Timing
Adjusting Fuel Timing
Decompression Device Adjustment
Fuel System
Fuel Bleeding
Oil Filter Change
Sea Water Pump and Impeller Replacement
Model 15 Sea Water Circulation Diagram
Model 12, 18, 20, 25, 25XP, 30, 40 & 50 Water
Fresh Water Circulation Diagram

Hurth Transmission
Periodic Service Chart for Engine
Marine Engine Warranty - Limited

Engine Specifications and Images
(by engine model)

M2-12
M3-20
M4-30
M-25XP
M-35
M-30
M-40
M-50
M-12
M-15
M-18
M-20
M-25

 

Electrical Equipment12 Volt - 51 Amp W/Glow Plugs(SAE 30 HD. (CD) or 10W40) CAUTION: FILL ONLY TO FULL MARK ON DIPSTICKLubrication (Trans.)FILL TO FULL RING ON DIPSTICK
UNIVERSAL MODEL M-18 SPECIFICATIONS
Pictorial views of this engine at the bottom of page.
Horsepower14 @ 3200
No. of Cylinders2
Bore x Stroke2.60 x 2.45
Cubic Inch35
Maximum R.RM.3200
Cruising Range (Approx.) 2100/2600 RPM
Compression Ratio 21:1
Lubrication (Eng. Approx. Ots.) 2.5 - 3.0
(Type AFT A or GM-DEXRON - II Do not mix different oils)
Transmission Reduction 2:1
Coolant FWC (50/50 Solution Approx.)3.0 Quarts
Exhaust Flange1 N.PI
Fuel Type#2 Diesel
Fuel FilterP/N 298854
Oil FilterP/N 300209
Eng. Operating Temp. Degrees F.165 to 195
Propeller RotationRight Hand
Weight (lbs.)255 lbs.
Injection NozzleP/N 299517 & 299518
Engine is governor controlled to prevent overspeed. It is recommended to carry the following extra parts should the need arise: V-Belt, Sea Water Pump Impeller, Fuel & Lube Oil Filters, 1 Qt. of Trans. Oil, 2 Ots. Lub. Oil and 1 Gal. 50/50 Coolant.  All pictorial views and specifications subject to change without notice.

M-15 Engine Image - Copyright 2000 All Rights Reserved TOAD Marine Supply